PDF associated:
/ZEROL PAG 150.PDF
SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 1 6 Four Seasons Part Numbers 59883 801653 4 26 2005 1 IDENTIFICATION OF THE SUBSTANCE PREPARATION AND COMPANY UNDERTAKING Product Name ZEROL PAG 150 Product Use Lubricant Supplier Shrieve Products International Ltd Suite 21 70 Churchill Square Kings Hill West Malling Kent ME19 4YU United Kingdom Contact Numbers Tel 1 800 367 4226 Tel 44 0 1732 520600 Fax 44 0 1732 520601 Emergency Telephone Number NCEC 44 0 1865 407333 2 COMPOSITION INFORMATION ON INGREDIENTS Chemical Characterisation Additional information Polyalkylene glycol Based on major component All components are either EINECS listed or classified as polymers Dangerous Components Product Name Oxirane methyl polymer with oxirane monobutyl ether CAS No 9038 95 3 Conc m m 5 9 Classification Xn R20 3 HAZARDS IDENTIFICATION Hazard description Not classified as hazardous 4 FIRST AID MEASURES General information Immediately remove any clothing soiled by the product After Inhalation Remove from exposure Supply fresh air If required provide artificial respiration Keep patient warm Consult doctor if symptoms persist After skin contact Immediately wash with water and soap and rinse thoroughly After eye contact Rinse opened eye for several minutes under running water Then consult a doctor SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 2 6 After swallowing Wash out the mouth with water Never administer anything by mouth if a casualty is losing consciousness is unconscious or is convulsing Do not induce vomiting call for medical help immediately Information for doctor Treat symptomatically 5 FIRE FIGHTING MEASURES Suitable Extinguishing Means Water spray alcohol resistant foam fire extinguishing powder carbon dioxide Unsuitable extinguishing media Water with full jet Special hazards caused by the substance its products of combustion or resulting gases Formation of toxic gases is possible during heating or in the case of fire Protective equipment Wear self contained breathing apparatus Additional information Keep containers and surroundings cool with water spray 6 ACCIDENTAL RELEASE MEASURES Personal Precautions Wear protective clothing Environmental Protection Measures for cleaning collecting Additional Information Do not allow product to reach sewage system or any watercourse Inform authorities in case of seepage into watercourse or sewage system Absorb with liquid binding material sand diatomite acid binders universal binders sawdust Send for recovery or disposal in suitable containers See Section 8 for information on personal protection equipment 7 HANDLING AND STORAGE Handling Information about fire and explosion protection Storage Requirements to be met by storerooms and receptacles Information about storage in one common storage facility Store in cool dry place in tightly closed containers Use only in well ventilated areas Avoid breathing mist or vapour from heated material Local exhaust ventilation should be provided if there is risk of mist or aerosol formation The product is not flammable Suitable storage materials are mild steel Stainless steel Store away from oxidising agents Store away from reducing agents SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 3 6 8 EXPOSURE CONTROLS PERSONAL PROTECTION Ingredients with limit values that require monitoring at the workplace The product does not contain any relevant quantities of materials with critical values that have to be monitored at the workplace Personal protective equipment General protective and hygienic measures Do not inhale gases fumes aerosols Avoid contact with eyes and skin Respiratory Protection Recommended filter device for short term use Respiratory protection if there is a risk of breathing mists or vapours from heated material Repiratory protection if there is risk of uncontrolled exposure to aerosols Combination filter A P3 Protection of hands material of gloves PVC gloves recommended material thickness 1 1 mm The selection of the suitable gloves does not only depend on the material but also on further marks of quality and varies from manufacturer to manufacturer Eye Protection Chemical goggles must be worn during all handling operations Body Protection Protective work clothing 9 PHYSICAL AND CHEMICAL PROPERTIES General Information Form Colour Odour Liquid Yellow Characteristic Change in condition Boiling point Boiling range Pour Point Decomposes before boiling 35 C Flash point COC 250 C ASTM D6450 Ignition temperature 370 C Self igniting Product is not self igniting Danger of explosion Product does not present an explosion hazard Vapour Pressure Neglible vapour pressure at ambient conditions Density at 20 C 1 051 g cm typical SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 4 6 Solubility in Miscibility with water Partially soluble Viscosity Kinematic at 40 C 150 mm 2 s typical 10 STABILITY AND REACTIVITY Thermal decomposition conditions to be avoided Stable under normal conditions Can decompose slowly with localised heating above 150 C Dangerous reactions Reacts with strong acids and oxidising agents Toxic fumes may be released if heated above the decomposition point Dangerous Decomposition Products Carbon monoxide and cabon dioxide Aldehyde 11 TOXICOLOGICAL INFORMATION Acute Toxicity Based on major component LD LC values relevant for classification Oral LD 50 rat 5000 mg kg Dermal LD 50 rabbit 5000 mg kg Primary irritant effect On the skin Repeated or prolonged contact may produce defatting of the skin leading to irritation and dermatitis On the eye May cause slight transient irritation Sensitisation No sensitising effects known Additional toxicological information Swallowing may have the following effects Irritation of mouth throat and respiratory tract Vomiting Diarrhoea Exposure to vapour at high concentrations may have the following effects irritation of nose throat and respiratory tract Low volatility makes acute effects unlikely at ambient temperatures Repeated exposure to aerosols may result in lung damage SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 5 6 12 ECOLOGICAL INFORMATION Behaviour in environmental systems Mobility and bioaccumulation potential Product is not expected to bioaccumulate Other information BOD20 5 ThOD Ecotoxical effects Aquatic toxicity The product is rated as non hazardous to aquatic species based on major component General Notes Water hazard class 1 German Regulations slightly hazardous for water Do not allow product to reach ground water watercourse or sewage system 13 DISPOSAL CONSIDERATIONS Product Recommendation Dispose of in accordance with all applicable local and national regulations Incineration is the recommended method of disposal Must not be disposed together with household rubbish Do not allow product to reach sewage system Uncleaned packaging Recommendation Labels should not be removed from containers until they have been cleaned Containers should be cleaned by appropriate methods and then re used or disposed of by landfill or incineration as appropriate Disposal must be in accordance with local regulations Recommended cleansing agents Water with cleansing agents if required 14 TRANSPORT INFORMATION Transport Additional information Not classified as dangerous for transport 15 REGULATORY INFORMATION Labelling according to EU guidelines The product is not subject to classification according to the calculation methods of the General Classification Guideline for Preparations of the EU as issued in the latest valid version SAFETY DATA SHEET According to 91 155 EC ZEROL PAG 150 Date Revised 26 04 05 Replaces Version of 15 12 03 Shrieve Products International Ltd Printed on 22 09 2006 Page 6 6 National Regulations All components listed USA TSCA Australia AICS Canada DSL Korea Philippines PICCS China 16 OTHER INFORMATION Revelant R phrases R 20 Harmful by inhalation SDS Distribution The information in this document should be made available to all who may handle the product SDS Preparation This Safety Data Sheet has been prepared in accordance with the requirements of the Data Sheet Directive 91 155 EEC and the amendments 93 112 EC and 2001 58 EC The information is based on the data of which we are aware and is believed to be correct as of the data hereof Since the information contained herein may be applied under conditions beyond our control and with which we may be unfamiliar and since data made available subsequent to the date hereof may suggest modification of the information we do not assume any responsibility for the result of its use This information is furnished upon condition that the person receiving it shall make their own determination of the suitability of the material for their particular purpose
