PDF associated:
/Vacuum Pump Oil.PDF
H1TMP209508 LFK INDUSTRIES INC 59091 VACUUM PUMP OIL MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59091 LFK Industries Inc Page 1 Section 1 PRODUCT AND COMPANY IDENTIFICATION Product Name 59091 Vacuum Pump Oil MANUFACTURER LFK Industries Inc 519 Gibson St Telephone Number Seagoville TX 76016 972 287 1200 Section 2 HAZARDOUS INGREDIENTS Case Number 64741 88 4 19210 06 1 68457 79 4 SHA Hazardous Components 29 CFR 1910 1200 Section 3 HAZARDS IDENTIFICATION EMERGENCY OVERVIEW Eye and skin irritant Harmful if swallowed Potential Health Effects Eyes Eye irritation develops immediately on contact Skin Causes mild skin irritation Ingestion Causes irritation of mouth and stomach May cause nausea vomiting Inhalation Unlikely Chronic None established Carcinogen listed by National Toxicology Program No I A R C No OSHA No Section 4 FIRST AID MEASURES Eyes Flush eyes immediately with water for at least 15 minutes or until irritation subsides If irritation persists consult a physician Skin Wash thoroughly with soap and water Remove contaminated clothing and wash before reuse If irritation or rash develops obtain medical assistance MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59091 LFK Industries Inc Page 2 Ingestion DO Not induce vomiting Get emergency medical attention If spontaneous vomiting occurs keep head below hips Aspiration of even small amounts of vomit into lungs may result in aspiration pneumonitis Inhalation Remove patient to fresh air and consult a physician If breathing is difficult give oxygen If not breathing give artifical respiration Section 5 FIRE FIGHTING MEASURES Flammable Properties Flash Point 424 degrees F Lower Exposure Limit Not determined Upper Exposure Limit Not determined Fire and Explosion Hazards Slightly combustible OSH NFPA Class IIIB Combustible Liquid If heated above its flash point will release flammable vapors which can burn in the open or be explosive in confined spaces if exposed to ignition source Mist or sprays may be flammable below oil s normal flash point Keep away from extreme heat or open flame Extinguishing Media Dry chemical Carbon Dioxide water fog and foam Note Water for and foam may cause frothing and spattering Fire Fighting Instructions Use water to cool containers exposed to flames Do not enter enclosed or a confined work space without proper protection equipment Fire fighting personnel should wear respiratory protection positive pressure if available Products of combustion includes acid smoke CO2 and toxic fumes of SOX ZNO POX Section 6 ACCIDENTAL RELEASE MEASURES Shut off ignition source Contain spill and keep from entering waterways or sewers Use personal protective equipment Advise EPA state agency if required Absorb on inert material Shovel sweep or vacuum spill Section 7 HANDLING AND STORAGE Handling and Storage precautions Avoid contact with skin eyes and clothing After handling this product wash hands before eating drinking or smoking If contact occurs remove contaminated clothing If needed take first aid action shone in section 4 Launder contaminated clothing before reuse Store in cool place away from ignition sources Store away from oxidizers MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59091 LFK Industries Inc Page 3 Work Hygienic Practices Wash hands with soap and water before eating drinking smoking or use of toilet facilities Do not use gasoline solvents kerosene or harsh abrasive skin cleaners for washing exposed skin areas Take a shower after work if general contact occurs Remove oil soaked clothing and launder before reuse Launder or discard contaminated shoes and leather gloves Section 8 EXPOSURE CONTROLS PERSONAL PROTECTION Engineering Controls Use adequate ventilation to keep oil mists of this material below applicable standard s Eye Face Protection Safety glasses or splash goggles Have suitable eye wash water available Skin Protection Avoid prolong and or repeated skin contact If prolonged contact cannot be avoided wear protection impervious gloves and clothing Acceptable materials for gloves are polyvinyl chloride neoprene nitrile polyvinyl alcohol viton Respiratory Protection Normally not required if adequate ventilation If occupational exposure limits are exceeded wear NIOSH MSHA apparatus Other General Protection If there is a likelihood of splashing an oil resistant clothing should be worn Never wear oil soaked clothing Launder or dry clean before wearing Discard oil soaked shoes Section 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance Light amber liquid Odor Light bland petroleum Odor Threshold N D Basic Physical Properties Physical State Liquid Boiling Point 221 degrees C Melting Point N A degrees F N A degrees C Vapor Pressure ND Vapor Density Air 1 ND Specific Gravity 88 Water 1 Solubility H2O negligible in water Percent Volatile nil Evaporation Rate BuAc 1 ND Viscosity 330 SUC at 100 degrees F MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59091 LFK Industries Inc Page 4 Section 10 STABILITY AND REACTIVITY Stability Stable Condition to Avoid stability Sources of ignition Incompatible Materials Strong oxidizers Hazardous decomposition Products Combustion may produce CO CO2 Toxic fumes of ZNO POX SOX Hazardous polymerization Will not occur Section 11 TOXICOLOGICAL INFORMATION Acute Studies Test on similar materials show a low order of acute oral and dermal toxicity LDLo 2130 mg kg oral rat Section 12 ECOLOGICAL INFORMATION Cab accumulate in some organisms but is not considered to be bio concentrative Section 13 DISPOSAL CONSIDERATIONS Follow federal state and local regulation Not a RCRA hazardous waste if uncontaminated If used RCRA Criteria must be determined Do not flush to drain storm sewer Contract to authorized disposal service If permitted incineration may be practical Recommend recycling RCRA Information Not a RCRA hazardous waste if uncontaminated Section 14 TRANSPORT INFORMATION Proper Shipping Name Not regulated by DOT Hazard Class Not applicable DOT Identification Number N A DOT Shipping Label Not regulated by DOT MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59091 LFK Industries Inc Page 5 Section 15 REGULATORY INFORMATION EPA TSCA Inventory The components of this product are listed on the EPA TSCA inventory chemicals EPA Hazard Classification Code Not Applicable Comprehensive Environmental Response Compensation and Liability Act CERCLA No chemicals in this product are subject to the reporting requirements of CERCLA SARA Title III Section 313 Supplier Notification No chemicals in this product exceed the DeMinimus reporting level established by SARA Title III Sec 313 and 40 CFR 372 California Proposition 65 Warning This product contains mineral oil a chemical to the state of California to cause cancer Section 16 OTHER INFORMATION NFPA Hazard Rating Health 1 Fire 1 Reactivity 0 Disclaimer of Expressed and Implied Warranties The information contained herein is based upon data believed to be reliable and reflects our best professional judgement Although reasonable care has been taken in the preparation of the document we extend no warranties and make no representation as to the accuracy or completeness of the information contained therein and assume no responsibility regarding the suitability of this information for the user s intended purpose or for the consequence of its use Each individual should make a determination as to the suitability of the information for his her particular purpose s
