PDF associated:
/Sunair Refrigerant Oil.PDF
MATERIAL SAFETY DATA SHEET Trade Name: Sunair Refrigerant Oil MSDS NO. 6912 Revision Date: 01/14/2006 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Trade Name: Sunair Refrigerant Oil Chemical Family: Refrigeration Oil Synonyms: None Emergency Telephone (24 hr.): CHEMTREC 1-800-424-9300 Supplier: TCC P.O. Box 139, Cleburne, Texas 76033 2. COMPOSITION/INFORMATION ON INGREDIENTS Ingredient/CAS No. wt. % OSHA PEL TWA OSHA PEL Ceiling Limits ACGIH TLV TWA ACGIH TLW STEL Heavy Hydrotreated Naphthenic Distillates (petroleum) 64742-52-5 95-100 Not known Mist 5 mg/m3 TLV Mist 5 mg/m3 8 HR. Not Known 3. HAZARDS IDENTIFICATION Emergency Overview: Prolonged or repeated skin contact may cause skin irritation. Primary Route of entry is Skin. Tests on similar materials suggest that no eye or skin short-term exposure effects are expected. Personnel with pre-existing skin disorders should avoid contact with this product. Tests on similar materials indicate no significant adverse effects expected by ingestion. This material is practically non-toxic. Harmful or fatal if liquid is aspirated into lungs. 4. FIRST AID MEASURES Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower lids. Seek medical attention if irritation persists. Ingestion: Product is practically non-toxic. DO NOT INDUCE VOMITING. Give nothing by mouth. Seek immediate medical attention. Inhalation: Not a hazard under normal use conditions. If overcome by vapor from hot product, immediately remove from exposure and call a physician. If breathing is irregular or has stopped, start resuscitation: administer oxygen, if available. If overexposed to oil mist, remove from exposure until excessive oil mist condition subsides. Skin Contact: Wash with soap and water. Remove contaminated clothing and launder before reuse. If product is injected into or under the skin, or into any part of the body, the individual should be evaluated immediately by a physician as a surgical emergency. 5. FIRE FIGHTING MEASURES Flammable Properties Flash Point °F(°C): >400 F Flash Point Method: TAG Closed Cup Flammable Limits in Air - Lower (%): Not Determined Flammable Limits in Air - Upper (%): Not Determined Autoignition Temperature °F(°C): > 650 F Extinguishing Media: Foam. Water fog. Dry chemical. Carbon dioxide. Use water spray to keep containers cool that are exposed to heat or flames. Protection Of Fire-Fighters: Special Fire-Fighting Procedures: Wear approved positive-pressure self-contained breathing apparatus and protective clothing. Hazardous Combustion Products: Fumes and Smoke. Carbon Monoxide. Aldehyes and other decomposition products, in the case of incomplete combustion. Aerosol Comments: Not Applicable 6. ACCIDENTAL RELEASE MEASURES Personal Precautions: Wear appropriate protective clothing and equipment to prevent skin and eye contact. Spill Procedures: Contain any liquid from leaking containers. Wear protective equipment specified. Only trained and qulified personel should handle any spilled or leaked product. Recover free product. Add sand, earth, or other suitable absorbent to spill area. Minimize skin contact. Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses, or extensive land areas. Assure conformity with applicable governmental regulations. Environmental Precautions: Do not allow to enter sanitary drains, sewer or surface and subsurface waters. 7. HANDLING AND STORAGE Handling and Keep container closed when not in use. Keep away from heat and open flame. Empty oil containers can contain explosive vapors. Page 1 of 3 Trade Name: Sunair Refrigerant Oil MSDS NO. 6912 Storage: NFPA Class IIIB storage. Wash thoroughly with soap and water after handling. Good hygienic practices should be observed. Work clothes should be washed seperately at the end of each work day. Disposable clothing should be discarded with material. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Engineering Controls: Use local exhaust. Eyewash stations. Eyes: Wear safety glasses or goggles to protect against exposure. Skin Protection: Use chemical resistant gloves for prolonged skin contact. Neoprene coated apron or clothing. Nitrile coated apron or clothing. PVC coated apron or clothing. Viton. Respiratory Protection: Use local exhaust to capture vapor, mists or fumes, if necessary. Provide ventilation sufficient to prevent exceeding recommended exposure limit or buildup explosive concentrations of vapor in air. No smoking, or use of flame or other ignition sources. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Colorless to light yellow liquid Odor: MILD PETROLEUM pH Value: Essentially neutral Vapor Pressure: <.0001 mm Hg @ 20 C Vapor Density (Air=1): >5 Boiling Point (°F): >630 F Melting/Freezing Point: Not determined. Solubility in Water: NEGLIGIBLE Bulk Density at 20°C: Not Determined Molecular Weight: 420 Evaporation Rate: 1000 x slower than ethyl ether Viscosity: 515 SUS @ 100 F (9.0 cSt @ 100 C) Specific Gravity (H20=1): .91 VOC Content(%): <1 % Decomposition Temperature: Not Known 10. STABILITY AND REACTIVITY Chemical Stability: STABLE. Conditions to Avoid: Keep away from heat,sparks and flame. Avoid any source of ignition. Materials to Avoid: Strong oxidizers such as liquid chlorine, concentrated oxygen, sodium hypochlorite, calcium hypochlorite, etc. , as this presents a serious explosion hazard. Hazardous Decomposition Products: Carbon monoxide. and other asphxiants. Hazardous Polymerization: WILL NOT OCCUR 11. TOXICOLOGICAL INFORMATION Toxicological Data: Ingredient/CAS No. wt. % Route Species Dose Heavy Hydrotreated Naphthenic Distillates (petroleum) 64742-52-5 95-100 NA NA Not known. Carcinogenicity: Ingredient/CAS No. wt. % IARC NTP OSHA Heavy Hydrotreated Naphthenic Distillates (petroleum) 64742-52-5 95-100 Not Listed Not Listed Not Listed 12. ECOLOGICAL INFORMATION Ecological testing has not been conducted on this product. 13. DISPOSAL CONSIDERATION Waste Classification: This product is not a RCRA hazardous waste if uncontaminated. If "used" RCRA criteria must be determined. Waste Management: Not determined. Disposal should be made in accordance with federal, state and local regulations. Page 2 of 3 Trade Name: Sunair Refrigerant Oil MSDS NO. 6912 14. TRANSPORTATION INFORMATION U.S. DOT: Proper Shipping Name: Not Regulated Hazard Class: Not Applicable UN/NA Number: Not Applicable DOT Packing Group: Not Applicable IMDG: Proper Shipping Name: Not Regulated Hazard Class: Not Applicable Hazard Subclass: Not Applicable UN No.: Not Applicable Packing Group: Not Applicable Marine Pollutant: No 15. REGULATORY INFORMATION US Federal Regulations: Ingredient/CAS No. wt. % SARA 313 SARA 302 RQ TPQ Heavy Hydrotreated Naphthenic Distillates (petroleum) 64742-52-5 95-100 Not Listed Not Listed NA NA SARA 311/312 Hazard Catagories: Not Determined. State Regulations: Ingredient/CAS No. wt. % California Prop. 65 Cancer list California Prop. 65 Developmental Toxicity California Prop. 65 Reproductive Female California Prop. 65 Reproductive Male Heavy Hydrotreated Naphthenic Distillates (petroleum) 64742-52-5 95-100 Not Listed Not Listed Not Listed Not Listed U.S. TSCA: The components of this product are listed on the TSCA Inventory. 16. OTHER INFORMATION General Notes: Do not allow undiluted material or large quantities to reach groundwater, bodies of water or sewer system. Disclaimer: The information and recommendations contained herein are based upon tests believed to be reliable. However, TCC does not guarantee their accuracy or completeness NOR SHALL ANY OF THIS INFORMATION CONSTITUTE A WARRANTY, WHETHER EXPRESSED OR IMPLIED, AS TO THE SAFETY OF THE GOODS, THE MERCHANTABILITY OF THE GOODS, OR THE FITNESS OF THE GOODS FOR A PARTICULAR PURPOSE. Adjustment to conform to actual conditions of usage may be required. TCC assumes no responsibility for results obtained or for incidental or consequential damages, including lost profits, arising from the use of these data. No warranty against infringement of any patent, copyright or trademark is made or implied. Page 3 of 3
