PDF associated:
/Paraffinic Refrigerant Oil.PDF
FOUR SEASONS PN 59001 LFK INDUSTRIES INC 59001 PARAFFINIC REFRIGERANT OIL MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 1 Section 1 PRODUCT AND COMPANY IDENTIFICATION Product Name 59001 Paraffinic Refrigerant Oil MANUFACTURER LFK Industries Inc 519 Gibson St Telephone Number Seagoville TX 76016 972 287 1200 Section 2 HAZARDOUS INGREDIENTS Case Number None Ingredient Name Daphne Hermetic Oil FD 46XG Exposure Limit Oil Mist OSHA PEL MIST 5 MG M3 8 HRS ACGIH TLV MIST 5 MG M3 8 HRS Concentration Percent by Volume 100 Section 3 HAZARDS IDENTIFICATION EMERGENCY OVERVIEW Not expected to cause a severe emergency hazard Potential Health Effects Primary route s of entry Skin Eyes Tests on similar materials suggest that no eye effect be expected Skin Test on similar materials indicate that no significant adverse health effects are expected to occur upon short term exposure Ingestion Test on similar materials indicate that no significant adverse effects expected Practically non toxic Inhalation Test on similar materials indicate that no significant adverse effects expected Chronic Cancer Information Prolonged and or repeated contact with this material may produce skin irritation and inflammation MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 2 Carcinogen listed by National Toxicology Program No I A R C No OSHA No ACGIH No This product does not require a cancer hazard warning in accordance with the OSHA Hazard Comm Std Medical Conditions Aggravated By Exposure Personnel with pre existing skin disorders should avoid contact with this product Section 4 FIRST AID MEASURES Eyes Flush eyes immediately with water for at least 15 minutes or until irritation subsides If irritation persists consult a physician Skin Wash thoroughly with soap and water Remove contaminated clothing and wash before reuse If irritation or rash develops obtain medical assistance Immediately remove soaked clothing Ingestion Product is practically non toxic Do not induce vomiting Obtain emergency medical attention Inhalation Not likely to occur except a mist Remove patient to fresh air and consult a physician If breathing is difficult give oxygen If not breathing give artifical respiration Section 5 FIRE FIGHTING MEASURES Flammable Properties Flash Point 200 degrees C Autoignition Not determined Flammability Class Not determined Explosive Power None Lower Exposure Limit Not determined Upper Exposure Limit Not determined Method used COC Fire and Explosion Hazards Slightly combustible If heated above its flash point will release flammable vapors which can burn in the open or be explosive in confined spaces if exposed to ignition source Mist or sprays may be flammable below oil s normal flash point Keep away from extreme heat or open flame Extinguishing Media Dry chemical Carbon Dioxide water fog and foam Note Water for and foam may cause frothing and spattering MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 3 Fire Fighting Instructions Use water to cool containers exposed to flames Do not enter enclosed or a confined work space without proper protection equipment Fire fighting personnel should wear respiratory protection positive pressure if available Products of combustion includes fumes smoke and carbon monoxide Section 6 ACCIDENTAL RELEASE MEASURES Shut off ignition source Contain spill and keep from entering waterways or sewers Use personal protective equipment Advise EPA state agency if required Absorb on inert material Shovel sweep or vacuum spill Section 7 HANDLING AND STORAGE Handling and storage precautions Keep away from flames sparks or hot services Never use a torch to cut or weld on or near container Empty oil containers can contain explosive vapors Wash thoroughly after handling Work Hygienic Practices Wash hands with soap and water before eating drinking smoking or use of toilet facilities Do not use gasoline solvents kerosene or harsh abrasive skin cleaners for washing exposed skin areas Take a shower after work if general contact occurs Remove oil soaked clothing and launder before reuse Launder or discard contaminated shoes and leather gloves Section 8 EXPOSURE CONTROLS PERSONAL PROTECTION Engineering Controls Use adequate ventilation to keep oil mists of this material below applicable standard s See Section on occupational exposure limits Eye Face Protection Safety glasses or splash goggles Have suitable eye wash water available Skin Protection Avoid prolong and or repeated skin contact If prolonged contact cannot be avoided wear protection impervious gloves and clothing Acceptable materials for gloves are polyvinyl chloride neoprene nitrile polyvinyl alcohol viton Respiratory Protection Normally not required if adequate ventilation If occupational exposure limits are exceeded wear NIOSH MSHA apparatus MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 4 Other General Protection If there is a likelihood of splashing an oil resistant clothing should be worn Never wear oil soaked clothing Launder or dry clean before wearing Discard oil soaked shoes Affix warning labels on containers in accordance with 29 CFR 1910 1200 Hazard Communication Standard Section 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance Clear pale straw to water white colored viscous liquid Odor Light bland petroleum Odor Threshold N D Basic Physical Properties Physical State Liquid Boiling Point Not determined Melting Point Not determined Vapor Pressure Not determined Vapor Density Not determined Specific Gravity 8740 Water 1 Solubility H2O Insoluble pH Not determined Section 10 STABILITY AND REACTIVITY Stability Stable Condition to Avoid stability Sources of ignition Incompatible Materials Strong oxidizers Hazardous decomposition Products Combustion may produce carbon monoxide and other asphyxiants Hazardous polymerization Will not occur MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 5 Section 11 TOXICOLOGICAL INFORMATION Acute Studies Test on similar materials show a low order of acute oral and dermal toxicity Eye Effects Minimal irritation on contact Skin Effects Practically non toxic if absorbed May cause mild irritation with prolonged and repeated contact Acute Oral Effects Test on similar materials indicate low order of acute oral toxicity Acute Inhalation Effects Low acute toxicity expected on inhalation This product is severely hydrotreated Severely hydrotreated naphthenis petroleum oil has not been found to be carcinogenic or a potential carcinogen This product is not listed as carcinogenic or a potential carcinogen by the National Toxicology Program by the I A R C monographs or by OSHA Section 12 ECOLOGICAL INFORMATION No Data Given Section 13 DISPOSAL CONSIDERATIONS Follow federal state and local regulation Not a RCRA hazardous waste if uncontaminated If used RCRA Criteria must be determined Do not flush to drain storm sewer Contract to authorized disposal service If permitted incineration may be practical Recommend recycling RCRA Information Not a RCRA hazardous waste if uncontaminated Section 14 TRANSPORT INFORMATION Proper Shipping Name Not regulated by DOT Hazard Class Not applicable DOT Identification Number N A DOT Shipping Label Not regulated by DOT MATERIAL SAFETY DATA SHEET Revised 12 01 99 MSDS ID 59001 LFK Industries Inc Page 6 Section 15 REGULATORY INFORMATION U S Federal Regulatory Information SARA 302 Threshold planning Quality Not applicable SARA 304 Reportable Quality Not applicable SARA 311 Categories Immediate Acute Health Effects N Delayed Chronic Health Effects N Fire Hazard N Sudden Release of Pressure Hazard N Reactivity Hazard N EPA TSCA Inventory The components of this product are listed on the EPA TSCA inventory chemicals EPA Hazard Classification Code Not Applicable Comprehensive Environmental Response Compensation and Liability Act CERCLA No chemicals in this product are subject to the reporting requirements of CERCLA SARA Title III Section 313 Supplier Notification No chemicals in this product exceed the DeMinimus reporting level established by SARA Title III Sec 313 and 40 CFR 372 WHMIS Classification Not Controlled Section 16 OTHER INFORMATION NFPA Hazard Rating Health 0 Negligible Fire 1 Slight Reactivity 0 Negligible Disclaimer of Expressed and Implied Warranties The information contained herein is based upon data believed to be reliable and reflects our best professional judgement Although reasonable care has been taken in the preparation of the document we extend no warranties and make no representation as to the accuracy or completeness of the information contained therein and assume no responsibility regarding the suitability of this information for the user s intended purpose or for the consequence of its use Each individual should make a determination as to the suitability of the information for his her particular purpose s
