PDF associated:
/ICE 32.PDF
MSDS ICE 32 Last printed 9 22 2006 10 00 00 AM 1 Four Seasons 69344 08 17 2006 MATERIAL SAFETY DATA SHEET 24 HOUR EMERGENCY ASSISTANCE GENERAL MSDS ASSISTANCE CHEMTREC 800 424 9300 SHRIEVE 800 367 4226 SHRIEVE 281 367 4226 For hazard identification acute and chronic health effects refer to the discussion in Section 3 SECTION 1 NAME PRODUCT ICE 32 CHEMICAL NAME Lubricant Additive Use Applications Performance Improvement SECTION 2 PRODUCT INGREDIENT THIS PRODUCT IS CONSIDERED AS NON HAZARDOUS SEE SECTION 14 COMPONENT CHEMICAL NAME BY WEIGHT Additive package Lubricant additives 100 Composition specific chemical identities are withheld as a trade secret under the provisions of OSHA hazard communication standard 29 CFR 1910 1200 SECTION 3 HAZARD IDENTIFICATION EMERGENCY OVERVIEW Appearance Ordinary oily odor clear yellow to golden colored liquid Hazardous Material Health 1 National Fire Protection Information System Fire 1 Association NFPA United States Reactivity 0 United States Personal protection POTENTIAL HEALTH EFFECTS Primary Route of Exposure Skin EFFECTS OF OVEREXPOSURE EYES Expected to cause no more than minor eye irritation Application of a similar product into the eyes of rabbits produced very slight membrane irritation without corneal injury Avoid eye contact as good industrial practice SKIN Not a primary skin irritant but may cause skin irritation on repeated or prolonged contact Application of a similar product onto the skin of rabbits produced slight erythmia and edema INHALATION Avoid breathing vapor or mist Under normal use conditions this product is not an inhalation hazard Prolonged exposure to vapors may cause dizziness and headaches INGESTION May cause nausea Not expected to be acutely toxic by ingestion There is no evidence that this product aggravates an existing medical condition OTHER REMARKS None MSDS ICE 32 Last printed 9 22 2006 10 00 00 AM 2 SECTION 4 FIRST AID MEASURES EYES Immediately flush eyes with plenty of water for at least 15 minutes while holding the eyelids open If irritation persists see a physician SKIN Remove contaminated clothing Wash skin thoroughly with soap and water Launder contaminated clothing See a doctor if irritation persists INGESTION If swallowed call a physician immediately ONLY induce vomiting at the instruction of a physician Never give anything by mouth to an unconscious person If medical advice cannot be obtained take the person product container and MSDS to the nearest medical emergency center INHALATION Remove to fresh air If not breathing give artificial respiration and seek medical attention immediately Remove material from eyes skin and clothing SECTION 5 FIRE FIGHTING MEASURES Flash Point degrees C Cleveland Open Cup 200C Flammable Limits Lower Upper Lower Not determined Upper Not determined Recommended Fire Extinguishing Agents and Special Procedures Use water spray dry chemical foam or carbon dioxide to extinguish flames Use water spray to cool fire exposed containers Water or foam may cause frothing Unusual or Explosive Hazards None Special Protective Equipment for Firefighters Wear full protective clothing and positive pressure breathing apparatus SECTION 6 ACCIDENTAL RELEASE MEASURES Procedures in Case of Accidental Release Breakage or Leakage Ventilate area Avoid breathing vapor Wear appropriate personal protective equipment including appropriate respiratory protection Contain spill if possible Wipe up or absorb on suitable material and shovel up Prevent entry into sewers and waterways Avoid contact with skin eyes or clothing SECTION 7 HANDLING AND STORAGE Precautions to be Taken in Handling Minimum feasible handling temperatures should be maintained Storage Periods of exposure to high temperatures should be minimized Water contamination should be avoided SECTION 8 EXPOSURE CONTROLS PERSONAL PROTECTION Protective Equipment Type Eye Face Protection Safety glasses chemical type goggles or face shield recommended to prevent eye contact Skin Protection Protective clothing such as coveralls or lab coats should be worn Launder or dry clean when soiled Gloves and boots resistant to chemicals and petroleum distillates required Exposed workers should wash exposed skin several times daily with soap and water Remove and dry clean or launder clothing soaked or soiled with this material before reuse Dry cleaning of contaminated clothing may be more effective than normal laundering Inform individuals responsible for cleaning of potential hazards associated with handling contaminated clothing Respiratory Protection Airborne concentrations should be kept to lowest levels possible If vapor dust or mist is generated and the occupational exposure limit of the product or any component of the product is exceeded use appropriate MSDS ICE 32 Last printed 9 22 2006 10 00 00 AM 3 NIOSH or MSHA approved air purifying or air supplied respirator after determining the airborne concentration of the contaminant Air supplied respirators should always be worn when airborne concentration of the contaminant or oxygen content is unknown Ventilation Local exhaust ventilation recommended if generating vapor dust or mist If exhaust ventilation is not available or inadequate use MSHA or NIOSH approved respirator as appropriate Exposure Limit for the Total Product None established for product SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance Ordinary oily odor clear liquid lubricant additive Boiling point deg C 300C 572F at atmospheric pressure lubricant additive Melting Freezing Point deg C Not determined Specific Gravity water 1 1 05 lubricant additive pH Not applicable Vapor Pressure Not determined Vapor Density Air 1 Not determined Solubility in Water Negligible Other None SECTION 10 STABILITY AND REACTIVITY Stability Stable thermal light Incompatibility May react with strong oxidizing materials Hazardous Decomposition Products Normal combustion forms carbon dioxide and water vapor Incomplete combustion can form carbon monoxide Hazardous Polymerization Will not occur SECTION 11 TOXICOLOGICAL INFORMATION TOXICOLOGICAL INFORMATION ANIMAL TOXICITY DATA Oral LD50 believed to be 5 g kg rat practically non toxic Inhalation Not determined Dermal LD50 believed to be 10 g kg rabbit practically non toxic IRRITATION INDEX ESTIMATION OF IRRITATION SPECIES Skin Draize believed to be between 3 5 rabbit moderately irritating maximum 8 Eyes Draize believed to be 15 rabbit no appreciable effect maximum 110 Sensitization Not determined Other This product or a component of this product has been shown to damage red blood cells or blood forming organs and has caused anemia in laboratory animals SECTION 12 DISPOSAL CONSIDERATIONS Waste Disposal Methods This product has been evaluated for RCRA characteristics and does not meet the criteria of a hazardous waste if discarded in its purchased form Under RCRA it is the responsibility of the user of the product to determine at the time of disposal whether the product meets RCRA criteria for hazardous waste This is because product uses transformations mixtures processes etc may render the resulting materials hazardous MSDS ICE 32 Last printed 9 22 2006 10 00 00 AM 4 Remarks None SECTION 13 TRANSPORT INFORMATION Transportation DOT Not regulated according to DOT IMDG Not regulated according to IMDG ICAO IATA Not regulated according to ICAO IATA TDG Not regulated according to TDG SECTION 14 REGULATORY INFORMATION FEDERAL REGULATIONS This product and or its components are considered non hazardous by the following standards OSHA Hazard Comm Standard Classification SARA Title III Section 311 Hazardous Categorization No chemicals subject to reporting per the following standards SARA Title III Section 302 304 Extremely Hazardous Substances SARA Title III Section 313 Toxic Chemical CERCLA 102 a DOT Hazardous Substances California Prop 65 States Right to Know Regulations State list CT Connecticut FL Florida IL Illinois MI Michigan LA Louisiana MA Massachusetts NJ New Jersey PA Pennsylvania RI Rhode Island INTERNATIONAL REGULATIONS TSCA Inventory Status This product or its components are listed on or are exempt from the Toxic Substance Control Act TSCA Chemical Substance Inventory Canadian Inventory Status This product or its components are listed on or are exempt from the Canadian Domestic Substance List DSL EINECS Inventory Status This product or its components are listed on or are exempt from the European Inventory of Existing Chemical Substances EINECS or the European List of Notified Chemical Substances ELINCS Australian Inventory Status Not determined Japan Inventory Status Not determined SECTION 15 ENVIRONMENTAL INFORMATION Biodegradability Estimated to be less than 40 degradation over a test period of more than 28 days Potential to Bioaccumulation This product is estimated to have a very slow rate of bioaccumulation Remarks None MSDS ICE 32 Last printed 9 22 2006 10 00 00 AM 5 SECTION 16 OTHER INFORMATION None Date of Revision August 16 2006 Supersedes April 23 2003 and older versions ICE32 Autoair LP 1717 Woodstead Court Suite 205 The Woodlands TX 77380 The information contained herein is based on the data available to us and is believed to be correct However ICE32 Autoair LP makes no warranty expressed or implied regarding the accuracy of these data or the results to be obtained from the use thereof ICE32 Autoair LP assumes no responsibility for injury from the use of the product described herein
