PDF associated:
/FLOW-RITE 1000-3FLO.pdf
MATERIAL SAFETY DATA SHEET 1000 3FLO Page 1 SECTION 1 PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME FLOW RITE 1000 3FLO PRODUCT CODE 1000 3FLO COMPANY S NAME ACE FUEL SYSTEMS ADDRESS A W A I COMPANY 206 N KANSAS ST COLUMBUS KS 66725 EMERGENCY PHONE 800 325 3888 INFORMATION PHONE 620 429 1000 SECTION 2 HAZARDS IDENTIFICATION Vashz INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE RESPIRATORY IRRITATION HEADACHE NAUSEA FATIGUE DROWSINESS IMPAIRED CO ORDINATION SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE SKIN CONTACT MAY DRY THE SKIN PROLONGED CONTACT MAY CAUSE IRRITATION EYES LIQUID OR VAPOR CAN IRRITATE SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE NOT EASILY ABSORBED SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE SKIN TO CRACK LEADING TO DERMATITIS INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE NOT A LIKELY ROUTE OF EXPOSURE IF SWALLOWED DO NOT INDUCE VOMITING SEEK IMMEDIATE MEDICAL ADVICE AND OR ATTENTION HEALTH HAZARDS ACUTE AND CHRONIC ACUTE EYE IRRITANT SKIN IRRITANT NARCOTIC IN HIGH CONCENTRATIONS CHRONIC LIVER AND KIDNEY DISEASE SKIN IRRITATION AND DERMATITIS CARCINOGENICITY NTP CARCINOGEN No IARC MONOGRAPHS No OSHA REGULATED No MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE ACUTE AND CHRONIC LIVER AND KIDNEY DISEASE ANEMIA SECTION 3 COMPOSITION INFORMATION ON INGREDIENTS VAPOR PRESSURE WEIGHT REPORTABLE COMPONENTS CAS NUMBER mm Hg 8 TEMP PERCENT PETROLEUM DISTILLATE 64742 48 9 2 68 100 OSHA PEL 300 PPM ACGIH TLV 300 PPM No toxic chemical s subject to the reporting requirements of section 313 of Title III and of 40 CFR 372 are present SECTION 4 FIRST AID MEASURES EMERGENCY AND FIRST AID PROCEDURES INHALATTON REMOVE TO FRESH AIR ADMINISTER OXYGEN IF NEEDED APPLY ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED GET MEDICAL ATTENTION SKIN WIPE OFF WITH TOWEL WASH WITH SOAP AND WATER GET MEDICAL ATTENTION IF IRRITATION PERSISTS EYES WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15 MINUTES GET MEDICAL ATTENTION SECTION 5 FIRE FIGHTING MEASURES MATERIAL SAFETY DATA SHEET 41000 3FLO Page 2 FLASH POINT 104 F METHOD USED TCC FLAMMABLE LIMITS IN AIR BY VOLUME LOWER 1 2 UPPER 9 6 EXTINGUISHING MEDIA FOAM ALCOHOL FOAM CO2 DRY CHEMICAL WATER FOG SPECIAL FIREFIGHTING PROCEDURES WATER SPRAY MAY BE INEFFECTIVE WATER MAY BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD UP AND EXPLOSION WHEN EXPOSED TO EXTREME HEAT IF WATER IS USED FOG NOZZLES PREFERRED WEAR GOGGLES AND SELF CONTAINED BREATHING APPARATUS UNUSUAL FIRE AND EXPLOSION HAZARDS KEEP CONTAINERS TIGHTLY CLOSED ISOLATE FROM HEAT SPARKS ELECTRICAL EQUIPMENT AND OPEN FLAME CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF IGNITED OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD SYMPTOMS MAY NOT BE READILY APPARENT OBTAIN MEDICAL ATTENTION SECTION 6 ACCIDENTAL RELEASE MEASURES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED AVOID BREATHING VAPORS VENTILATE AREA DIKE AREA TO CONTAIN SPILL CLEAN UP AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL SECTION 7 HANDLING AND STORAGE PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING STORE AND USE IN COOL DRY WELL VENTILATED AREAS KEEP CONTAINERS CLOSED WHEN NOT IN USE KEEP AWAY FROM EXCESSIVE HEAT OR OPEN FLAME VAPORS MAY IGNITE EXPLOSIVELY VAPORS MAY SPREAD LONG DISTANCES PREVENT BUILD UP OF VAPORS EXTINGUISH ALL PILOT LIGHTS AND TURN OFF HEATERS NON EXPLOSION PROOF ELECTRICAL EQUIPMENT AND IGNITION SOURCES DURING USE SECTION 8 EXPOSURE CONTROL PERSONAL PROTECTION PRECAUTIONS KEEP CLOSURE TIGHT AND CONTAINER UPRIGHT TO PREVENT LEAKAGE OPEN CONTAINER SLOWLY GROUND CONTAINERS WHEN FILLING OR EMPTYING DO NOT GET iN EYES AVOID SKIN CONTACT AND CONTACT WITH CLOTHING DO NOT WELD OR FLAME CUT AN EMPTY DRUM DO NOT TAKE INTERNALLY DO NOT TRANSFER CONTENTS TO UNLABELLED CONTAINERS RESPIRATORY PROTECTION IN RESTRICTED AREAS USE APPROVED CHEMICAL MECHANICAL FILTERS DESIGNED TO REMOVE A COMBINATION OF PARTICLES AND VAPOR IN CONFINED AREAS USE APPROVED AIR LINE TYPE RESPIRATOR OR HOOD SELF CONTAINED BREATHING APPARATUS IS REQUIRED FOR VAPOR CONCENTRATIONS ABOVE PEL TLV LIMITS VENTILATION SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS GENERAL DILUTION AND OR LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL TLV OF MOST HAZARDOUS INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT PROTECTIVE GLOVES SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED CONTACT EYE PROTECTION SAFETY GLASSES WITH SPLASH GUARDS OR FULL FACE SHIELD OTHER PROTECTIVE CLOTHING OR EQUIPMENT SOLVENT RESISTANT APRON WORK HYGIENIC PRACTICES EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED MATERIAL SAFETY DATA SHEET Page 3 41000 3FLO SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES BOILING RANGE 325 349 F SPECIFIC GRAVITY H20 1 0 75 VAPOR DENSITY HEAVIER THAN AIR EVAPORATION RATE SLOWER THAN ETHER SOLUBILITY IN WATER NIL APPEARANCE AND ODOR COLORLESS LIQUID TYPICAL SOLVENT ODOR SECTION 10 STABITITY AND REACTIVITY STABILITY STABLE CONDITIONS TO AVOID APPLICATION TO HOT SURFACES INCOMPATIBILITY MATERIALS TO AVOID UNKNOWN HAZARDOUS DECOMPOSITION OR BYPRODUCTS MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION FUMES MAY CONTAIN CARBON MONOXIDE AND OTHER TOXIC FUMES HAZARDOUS POLYMERIZATION WILL NOT OCCUR SECTION 11 TOXICOLOGICAL INFORMATION LONG TERM TOXICOLOGICAL STUDIES HAVE NOT BEEN CONDUCTED FOR THIS PRODUCT SECTION 12 ECOLOGICAL INFORMATION LONG TERM ECOLOGICAL STUDIES HAVE NOT BEEN CONDUCTED FOR THIS PRODUCT SECTION 13 DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND FEDERAL REGULATIONS BEFORE ATTEMPTING CLEAN UP REFER TO OTHER SECTIONS OF THIS MSDS FOR HAZARD CAUTION INFORMATION SECTION 14 TRANSPORT INFORMATION BY LAND NOT REGULATED BY WATER DOT PROPER SHIPPING NAME UN 1268 PETROLEUM DISTILLATES n o s 3 PG III LTD QTY BY AIR DOT PROPER SHIPPING NAME UN1268 PETROLEUM DISTILLATES n o s 3 PG III LTD QTY Packing instruction Y309 applies SECTION 15 REGULATORY INFORMATION ALL INGREDIENTS ARE EITHER LISTED ON THE TSCA INVENTORY OR ARE EXEMPT SECTION 16 OTHER INFORMATION DATE PRINTED 04 28 08 NAME OF PREPARER ESP HMIS CODES H 1 F 2 R 0 P THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE HOWEVER NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF BECAUSE THE INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL WE ASSUME NO RESPONSIBILITY FOR ITS USE
