PDF associated:
/EMKAROX (R) PAG 100.PDF
FOUR SEASONS PN 59002 ICI AMERICAS INC EMKAROX r PAG 100 MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 1 Section 1 PRODUCT AND COMPANY IDENTIFICATION Product Name EMKAROX R PAG 100 MANUFACTURER ICI AMERICAS INC 3411 Silverside Rd Wilmington Delaware 19810 ICI Operator 24hr 302 887 3000 Medical Emergency 24 hr 800 228 5635 Extension 181 Chemical Emergency 24 hr Involving Transportation Spills Leaks Fires Accidents 800 424 9300 EMKARATE R PAG 100 General Use Refrigeration Lubricant Section 2 HAZARDOUS INGREDIENTS Ingredients w w OSHA PEL Polyoxoalkylene glycol ether 98 5 to 99 0 Not listed plus additives including TriCresylphosphate Cas 1330 78 5 1 0 to 1 5 Not listed 1 ortho isomer Ingredients not precisely identified are proprietary or nonhazardous Section 3 HAZARDS IDENTIFICATION EMERGENCY OVERVIEW Appearance Colorless liquid with characteristic odor Physical Hazards None Health Hazards Mild skin irritant Hazard Summary as defined by OSHA Hazard Comm Std 29 CFR 1910 1200 Potential Health Effects General This health hazard assessment is based on a consideration of the composition of this product Repeated or prolonged skin contact may result in mild irritation Read the entire MSDS for a more thorough evaluation of the hazards MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 2 Section 4 FIRST AID MEASURES Skin Contact Remove contaminated clothing Wash material off of skin with plenty of soap and water If redness itching or a burning sensation develops get medical attention Wash contaminated clothing and decontaminate footwear before reuse Eye Contact Irrigate with eyewash solution or clean water holding eyelids apart for at least 15 minutes If redness itching or a burning sensation develops have eyes examined and treated by medical personnel Ingestion DO NOT induce vomiting Never give anything to an unconscious person Wash out mouth with water and give 1 or 2 glasses of water to drink If gastrointestinal symptoms develop consult medical personnel Inhalation Remove patient from exposure If a cough or other respiratory symptoms develop consult medical personnel Note to Physician This material is considered to be only slightly toxic The potential complications associated with removing material from the GI tract the amount digested and the time since ingestion should be taken into account when developing a treatment plan Section 5 FIRE FIGHTING MEASURES Fire and Explosion Hazards Low fire hazard Unlikely to ignite except in high heat flux conditions Thermal decomposition will evolve irritant vapors Extinguishing Media Carbon dioxide dry chemical or appropriate foam If water is used use with care to avoid possible violent production of steam Fire Fighting Equipment Use self contained breathing apparatus with full facepiece and protective clothing Flash Point Deg C 245 COC Autoignition temperature Not determined Flammable Limits Not determined Explosive Power None Combustion Products Oxides of phosphorus and carbon NFPA Hazards Health 2 Flammability 1 Reactivity 1 Special Hazard None MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 3 Section 6 ACCIDENTAL RELEASE MEASURES Wear skin protection during clean up Contain and absorb large spillages onto an inert non flammable absorbent carrier such as earth or sand Do not allow to enter drains sewers or waterways Shovel into a chemical waste container for disposal or recovery Section 7 HANDLING AND STORAGE Handling Avoid prolonged or reocurring skin contact Avoid inhalation of high concentrations of mists or vapors Storage Requirements Avoid ingress of moisture by keeping containers properly sealed when not in use Product application requires that the product remain dry and free of excessive moisture pick up Keep away from strong oxidizing agents Suitable Containers Mild steel Storage Temperature Ideal storage temperature is 60 to 100 deg F Storage Life Two years minimum Section 8 EXPOSURE CONTROLS PERSONAL PROTECTION Exposure guidelines No OSHA PELs or ACGIH TLVs have been assigned Minimize exposure in accordance with good industrial hygiene practice Engineering controls Use ventilation adequate to maintain safe levels Provide eyewash station and safety shower in work area Respiratory protection Not normally needed if controls are adequate If needed use MSHA NIOSH approved respirator for organic vapors Protective clothing Gloves determined to be impervious under conditions of use neoprene Depending on conditions of use additional protection may be required such as apron arm covers or full body suit Wash contaminated clothing before rewearing Eye protection Chemical tight goggles Other protective equipment Eye wash station and safety shower in work area Section 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance Colorless liquid Odor Characteristic MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 4 Flash Point deg C 245 COC Boiling Point 200 Vapor pressure mmHg at 20 deg C 5 Vapor density air 1 1 0 Specific gravity 20 20 deg C No Data Density 15 deg C 1 027 Solubility in water Negligible Solubility other No data Pour Point deg C 40 Kinematic viscosity cSt at 40 deg C 100 Section 10 STABILITY AND REACTIVITY Stability Stable under normal conditions Incompatibility Strong oxidizing agents Hazardous decomposition products Highly unlikely under intended handling and use See section 5 Hazardous polymerization Will not occur Section 11 TOXICOLOGICAL INFORMATION No toxicity information is available on this specific preparation This health hazard assessment is based on information that is available on its components Possible Human Health Effects General There is evidence that tricresylphosphate has produced depressed cholinesterase levels in test animals Inhalation High concentrations of mist may be slightly irritant to the upper respiratory tract Thermal decomposition will evolve irritant vapors Skin contact Repeated or prolonged skin contact may result in irritation Not a skin irritant per OSHA Hazard Communication Standard 29 CFR 1910 1200 It is not a skin sensitiser in animal tests Eye Contact Practically non irritating to eyes Ingestion Low oral toxicity Carcinogencity The ingredients of this product are not classified as carcinogenic by ACGIH or IARC not regulated as carcinogens by OSHA and not listed as carcinogens by NTP MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 5 Other effects of overexposure No other adverse clinical effects are known to be associated with exposures to this material However because exposure potential is a critical element in the expression of a potential health hazard this product if handled in accordance with good industrial hygiene practices will not present an actual hazard in the workplace Section 12 ECOLOGICAL INFORMATION Persistence and degradation Not determined Effect on effluent treatment Not determined Section 13 DISPOSAL CONSIDERATIONS Disposal method Discarded product is not a hazardous waste under RCRA 40 CFR 261 Container disposal Empty container retains product residue Observe allhazard precautions Do not distribute make available furnish or reuse empty container except for storage and shipment of original product Remove all product residue from container and puncture or otherwise destroy empty container before disposal Section 14 TRANSPORT INFORMATION DOT IMO IATA ICAO class Not regulated Section 15 REGULATORY INFORMATION OSHA Classification Physical Not Regulated Health Not Regulated TSCA Toxic Substances Control Act Regulations All ingredients are on the TSCA Chemical Substance Inventory CERCLA and SARA Regulations 40 CFR 355 370 and 372 This product does not contain any chemicals subject to the reporting requirements of SARA Section 313 IARC Classification None of the components of this product are listed on IARC MATERIAL SAFETY DATA SHEET Revised 2 09 99 MSDS ID 37812 ICI AMERICAS INC Page 6 IARC Classification None of the components of this product are listed on IARC Section 16 OTHER INFORMATION HMIS Ratings Health Hazard 1 Flammability Hazard 1 Reactivity Hazard 0 Personal Protection B See Section 8 of the MSDS The information herein is given in good faith but no warranty expressed or implied is made This line or section contains revisions or new statements since the last issue date
